Ad closing in seconds....

Bridgestone explains Assen tyre issues

Published: 06 July 2012

Updated: 24 November 2014

Bridgestone has revealed the findings of a detailed analysis of the badly chunked rear tyres that struck Valentino Rossi and Ben Spies during last weekend’s historic Dutch TT at Assen.

Rossi was forced to pit for a new rear tyre while he was battling for a top five finish after he lost large chunks of rubber of his Bridgestone tyre.

And Texan Spies saw his hopes of claiming a first rostrum of the season ended after he lost large chunks off his rear tyre while battling for third with Italian Andrea Dovizioso.

Bridgestone immediately sent the affected tyres back to its Technical Centre in Kodaira, Japan, where they underwent intensive analysis to determine the cause of the irregularities.

Bridgestone’s Manager of Motorsport Tyre Development, Shinji Aoki, was closely involved in the analysis of the rear tyres he explained what the contributing factors were at Assen that caused the problems in the rear tyres, and what measures Bridgestone will take to prevent such occurrences in future.

He said: “There were three riders who had problems with the right shoulder of their rear tyre at Assen during the race, namely chunking of a piece of the tyre’s tread due to excessive heating of the rear tyre.

"Fortunately, none of the riders that experienced this issue crashed and the inner pressure of their tyres remained normal. At Assen there were some factors that contributed to this potential increase in rear tyre temperature.

"Compared to last year, the ambient temperature was substantially higher, the capacity of the engines in MotoGP machines has increased from 800cc to 1000cc which brought with it an increase in torque and machine weight, while the layout of the circuit also changed which resulted in a marked improvement in lap times.

"All these factors, in addition to the high camber of the Assen circuit, contributed to an increase in the potential for higher rear tyre temperatures and when combined with certain bike setups and riding styles, resulted in excessive heat build-up that caused tread chunking of some rider’s rear tyres.

"Though we were aware that this year’s Dutch TT would run under different circumstances due to the aforementioned changes in MotoGP machinery and weather conditions, we could not anticipate that these changes when combined with certain other variables such as particular riding styles and machine setup would result in such irregular rear tyre behaviour.”

Aoki said the thorough investigation of the tyres had not uncovered a defect with the tyre or a manufacturing fault and he added: “We performed detailed analysis of the affected MotoGP rear tyres from Assen, as well as other rear tyres from the same batch as the affected tyres and compared our results with analysis of a control set of tyres from another production batch.

"All these tyres underwent extensive testing, including a simulation on a specialised test rig that uses a drum rotated at high speed to test the durability and operating behaviour of each tyre.

"This analysis definitively showed that there was no manufacturing fault with the tyres supplied at Assen.”

And speaking about future measure to prevent a repeat of the Assen problems, Aoki said: “Bridgestone will re-analyse its data from each circuit, including Assen, and use the lessons we have learned from last week’s Dutch TT to carefully consider the safety requirements and tyre severity ratings for each circuit and will then decide if any additional events on the calendar should also be supplied with special construction tyres.

"The difference in construction between last year’s tyres and the 2012 specification was not a contributing factor to the generation of extreme temperatures on the edge of the tyre and this was confirmed during evaluation of both specification tyres on the rolling drum test rig.

"The construction of the 2012 specification tyres does enable quicker warm-up performance, but this revised construction was not a factor in the excessive tyre heating that caused the problems experienced at Assen.”

Aoki said Bridgestone was not anticipating any issues during this weekend’s German Grand Prix at Sachsenring, which puts extra stress on the left shoulder of the tyre with the tight and twisty layout dominated by left-handers.

“At Sachsenring it is usual for tyre temperatures to be higher than at other circuits, so for this event we traditionally have supplied special construction tyres that are specifically developed to handle extreme heat levels.

"So although relatively high tyre temperatures are expected this weekend during the German Grand Prix, the tyres supplied for this event are more than able to cope with this increase.”

Bauer Media

Bauer Media Group consists of: Bauer Consumer Media Ltd, Company number: 01176085, Bauer Radio Ltd, Company Number: 1394141
Registered Office: Media House, Peterborough Business Park, Lynch Wood, Peterborough, PE2 6EA H Bauer Publishing,
Company Number: LP003328 Registered Office: Academic House, 24-28 Oval Road, London, NW1 7DT.
All registered in England and Wales. VAT no 918 5617 01
Bauer Consumer Media Ltd are authorised and regulated by the FCA(Ref No. 710067)